Automate AM1.5 User's Guide download pdf (Page 24)

– 14 –

DETERGENT, RINSE AID, SANITIZER DISPENSERS — TUBING INSTALLATION

Detergent, rinse aid and / or sanitizer dispensers (not provided by Hobart) must have all connections

sealed against leakage.

The dishwasher uses 0.74 gallons of rinse water per rack at a

ow rate of 4.4 gallons per minute at 20 psig owing pressure

(equivalent to a maximum head pressure of 46 feet of water).

This information is used when setting the detergent, rinse aid

or sanitizer pumps.

Detergent Dispenser

The dishwasher has two

⁄8" diameter plugged holes, one on

the rear of the chamber and one on the lower part of the tank

near the pump (Fig. 19). With the tank empty, remove both

plugs to install the detergent dispenser.

 • Thechamberholeisforinstallationofthedetergentfeeder

tube.

 • Thelowertankholeisusedforinstallationofthedetergent

sensor.

Rinse Aid Dispenser

The rinse line ange connector on top of the dishwasher has two

⁄8" NPT pipe plugs (Fig. 20).

 • Remove the plug(s) (Fig. 20) for installation of the rinse aid

dispenser tube and / or chemical sanitizer tube, as needed.

Chemical Sanitizer Dispenser

When the dishwasher is to be operated in the chemical sanitizing

mode, the machine must be converted to low-temperature

sanitization (refer to Setup, page 16). A chemical sanitizer

dispenser that has been tested and certied by NSF International

must be installed.

 • Remove the pipe plug (Fig. 20) for installation

of the chemical sanitizer tube. To assure an

unobstructed flow of sanitizer, locate the

sanitizer tube in the center of water ow by

drilling the sanitizer tube tting so that its inside

diameter is equal to the outside diameter of the

tube. Slide the tube into the ange until it

touches the opposite side and then pull it back

out

⁄4 inch (Fig. 21).

 • Rate for 6% Sodium hypochlorite (bleach) —

3 ml. within 10 seconds (maximum).

 • Ratefor8.4%Sodiumhypochlorite(bleach)—

2 ml. within 10 seconds (maximum).

Fig. 19

Fig. 20

Fig. 21

DETERGENT SENSOR PORT

PIPE PLUGS

AM15 Dishwasher Technical Manual Page 24 of 83

1 2 ... 19 20 21 22 23 24 25 26 27 28 29 ... 82 83

Comments to this Manuals

No comments

Automate AM1.5 User's Guide Page 24

Comments to this Manuals

Related products and manuals for Car alarm Automate AM1.5